Dodge WC-24/WC-7 Command car -project
- 17thAirborne
- G-Lieutenant General
- Posts: 5847
- Joined: Mon Jun 21, 2004 5:42 am
- Location: Central TN
Re: Dodge WC-24/WC-7 Command car -project
The TM indicates 7/16-20 bolts and nuts, but does not specify a length. the washer as listed as 2" diameter.. The cotter pin is listed a 3/32 x 1 1/2" I measured the one I have and it is 3 1/4" long. the spacer ID accepts the bolt and it's OD is 5/8 and 2 1/4" long.
Oz
Feb 43 GPW 98532 USA 20206257
Oct 70 Land Rover Series 2a 25334079G NZ16GF36
http://gpw.castraponere.com/ (My Restoration Page)
Feb 43 GPW 98532 USA 20206257
Oct 70 Land Rover Series 2a 25334079G NZ16GF36
http://gpw.castraponere.com/ (My Restoration Page)
- 17thAirborne
- G-Lieutenant General
- Posts: 5847
- Joined: Mon Jun 21, 2004 5:42 am
- Location: Central TN
Re: Dodge WC-24/WC-7 Command car -project
Was looking at your engine photos. when i took the timing chain cover off my engine looked the same. Lots of baked on carbon and oil. The timing chain was loose as well, and I'm replacing it also. Check your valves in the guides as mine had lots of noticeable side to side play, so the guides will be replaced. Ca'n wait to see your engine progress.
Are you painting gray or silver?
Are you painting gray or silver?
Oz
Feb 43 GPW 98532 USA 20206257
Oct 70 Land Rover Series 2a 25334079G NZ16GF36
http://gpw.castraponere.com/ (My Restoration Page)
Feb 43 GPW 98532 USA 20206257
Oct 70 Land Rover Series 2a 25334079G NZ16GF36
http://gpw.castraponere.com/ (My Restoration Page)
-
- G-Command Sergeant Major
- Posts: 229
- Joined: Mon Nov 29, 2010 7:00 am
- Location: Hereford,U.K.
Re: Dodge WC-24/WC-7 Command car -project
Yes Oz,the timing chain was covered in carbon and oil ,didn't look as though it had been changed in a long time..its definatly being changed,also when i did a compression check before taking the head off i had bad or no compression ,when i took the valve cover off i noticed the valves where sticking ,I've not checked to see if there is any movement in them but I'm going to replace them anyway.17thAirborne wrote: ↑Thu Dec 07, 2017 6:00 amWas looking at your engine photos. when i took the timing chain cover off my engine looked the same. Lots of baked on carbon and oil. The timing chain was loose as well, and I'm replacing it also. Check your valves in the guides as mine had lots of noticeable side to side play, so the guides will be replaced. Ca'n wait to see your engine progress.
Are you painting gray or silver?
I will need that engine stand and a valve compression tool to go any further though,so that may be in a few months now.
I will be interested to see your engine when you get it back..
94 locating Regt RA,57 Bty B troop 1982-1985.
32 Heavy Regt RA,57 Bty D droop 1985-1990.
M38 1952 ,restoration project
Dodge 1/2 ton WC-24 Chassis WC-6 body..combo.
Dodge 1951 M43 ,SOLD
Harley Davidson WLA.type IV. SOLD
32 Heavy Regt RA,57 Bty D droop 1985-1990.
M38 1952 ,restoration project
Dodge 1/2 ton WC-24 Chassis WC-6 body..combo.
Dodge 1951 M43 ,SOLD
Harley Davidson WLA.type IV. SOLD
- 17thAirborne
- G-Lieutenant General
- Posts: 5847
- Joined: Mon Jun 21, 2004 5:42 am
- Location: Central TN
Re: Dodge WC-24/WC-7 Command car -project
i am hoping to get some pics while in the shop at each stage. will post in my thread.
Oz
Feb 43 GPW 98532 USA 20206257
Oct 70 Land Rover Series 2a 25334079G NZ16GF36
http://gpw.castraponere.com/ (My Restoration Page)
Feb 43 GPW 98532 USA 20206257
Oct 70 Land Rover Series 2a 25334079G NZ16GF36
http://gpw.castraponere.com/ (My Restoration Page)
- jeepfinger
- G-Colonel
- Posts: 1587
- Joined: Sun Jan 11, 2009 11:54 am
- Location: Bronte Country West Yorkshire England.
Re: Dodge WC-24/WC-7 Command car -project
Hi Paul,
Just getting into your rebuild, doing a great job The Dodge stuff is so much bigger than jeep stuff
Just found a photo of another 1/2 ton CC. Something to aim for She is from the North of England, you probaly know it?
Just getting into your rebuild, doing a great job The Dodge stuff is so much bigger than jeep stuff
Just found a photo of another 1/2 ton CC. Something to aim for She is from the North of England, you probaly know it?
- Attachments
-
- blackfell2.jpg (145.86 KiB) Viewed 17193 times
Dave Boocock
GPW 41158 June 19 1942
Bantam T3 9555 1/11/1943 USA 0258448
BSA WDM20 Sept 1940 C4343114
GPW 41158 June 19 1942
Bantam T3 9555 1/11/1943 USA 0258448
BSA WDM20 Sept 1940 C4343114
-
- G-Command Sergeant Major
- Posts: 229
- Joined: Mon Nov 29, 2010 7:00 am
- Location: Hereford,U.K.
Re: Dodge WC-24/WC-7 Command car -project
Hi thanks for the compliment,Bigger than rebuilding my Harley as well..jeepfinger wrote: ↑Fri Dec 08, 2017 11:54 amHi Paul,
Just getting into your rebuild, doing a great job The Dodge stuff is so much bigger than jeep stuff
Just found a photo of another 1/2 ton CC. Something to aim for She is from the North of England, you probaly know it?
Yes nice 1/2 Ton there,shame about the tyres..looks like a WC24 ,and no i don't know it,there are actually quite a few around,you just don't see them at the shows.
Im slowly getting there,its quite exiting finishing things and standing back to admire the progress,even if it has been a long process,still a long way to go ,did you check out Zephs WC16 rebuild..! very nice.worth a look.
94 locating Regt RA,57 Bty B troop 1982-1985.
32 Heavy Regt RA,57 Bty D droop 1985-1990.
M38 1952 ,restoration project
Dodge 1/2 ton WC-24 Chassis WC-6 body..combo.
Dodge 1951 M43 ,SOLD
Harley Davidson WLA.type IV. SOLD
32 Heavy Regt RA,57 Bty D droop 1985-1990.
M38 1952 ,restoration project
Dodge 1/2 ton WC-24 Chassis WC-6 body..combo.
Dodge 1951 M43 ,SOLD
Harley Davidson WLA.type IV. SOLD
- jeepfinger
- G-Colonel
- Posts: 1587
- Joined: Sun Jan 11, 2009 11:54 am
- Location: Bronte Country West Yorkshire England.
Re: Dodge WC-24/WC-7 Command car -project
Hi Paul,
Your welcome, not much smaller than a Motorbike, but even then, they can take awhile
The photo of the 1/2, I saw it on the HMVF forum, I think that it was at an event at Steve Carr's daugthers school. I asked him to use the photo. I did see Zephs CC, Posted a photo of a 1/2 ton CC that I saw when in Australia, it had side screens, they look ugly. I check out all of Zephs threads, good craftmanship, and he never has any help, apart from the dogs
I spend too much time looking at peoples resto's instead of doing my own
Ok, keep up the good work, really enjoying it.
Dave
Your welcome, not much smaller than a Motorbike, but even then, they can take awhile
The photo of the 1/2, I saw it on the HMVF forum, I think that it was at an event at Steve Carr's daugthers school. I asked him to use the photo. I did see Zephs CC, Posted a photo of a 1/2 ton CC that I saw when in Australia, it had side screens, they look ugly. I check out all of Zephs threads, good craftmanship, and he never has any help, apart from the dogs
I spend too much time looking at peoples resto's instead of doing my own
Ok, keep up the good work, really enjoying it.
Dave
Dave Boocock
GPW 41158 June 19 1942
Bantam T3 9555 1/11/1943 USA 0258448
BSA WDM20 Sept 1940 C4343114
GPW 41158 June 19 1942
Bantam T3 9555 1/11/1943 USA 0258448
BSA WDM20 Sept 1940 C4343114
-
- G-Command Sergeant Major
- Posts: 229
- Joined: Mon Nov 29, 2010 7:00 am
- Location: Hereford,U.K.
Re: Dodge WC-24/WC-7 Command car -project
Ok heres a new post,I've been working away a lot so haven't got to do much at all,so today i decided to open up my transfer case to see what it was like,and I'm glad to say it looks great,although i do have a couple of chipped teeth on what i think is the drive gear,so I'm hoping i can get away with not replacing it,it doesn't look too bad.
Pictures attached.
Pictures attached.
94 locating Regt RA,57 Bty B troop 1982-1985.
32 Heavy Regt RA,57 Bty D droop 1985-1990.
M38 1952 ,restoration project
Dodge 1/2 ton WC-24 Chassis WC-6 body..combo.
Dodge 1951 M43 ,SOLD
Harley Davidson WLA.type IV. SOLD
32 Heavy Regt RA,57 Bty D droop 1985-1990.
M38 1952 ,restoration project
Dodge 1/2 ton WC-24 Chassis WC-6 body..combo.
Dodge 1951 M43 ,SOLD
Harley Davidson WLA.type IV. SOLD
- 17thAirborne
- G-Lieutenant General
- Posts: 5847
- Joined: Mon Jun 21, 2004 5:42 am
- Location: Central TN
Re: Dodge WC-24/WC-7 Command car -project
Look forward to seeing this together! Looks clean inside.
Oz
Feb 43 GPW 98532 USA 20206257
Oct 70 Land Rover Series 2a 25334079G NZ16GF36
http://gpw.castraponere.com/ (My Restoration Page)
Feb 43 GPW 98532 USA 20206257
Oct 70 Land Rover Series 2a 25334079G NZ16GF36
http://gpw.castraponere.com/ (My Restoration Page)
-
- G-Command Sergeant Major
- Posts: 229
- Joined: Mon Nov 29, 2010 7:00 am
- Location: Hereford,U.K.
Re: Dodge WC-24/WC-7 Command car -project
Hi Oz,
I didn't know what to expect going by other peoples transfer cases,so i had my fingers crossed,it looks great,all the bearings and seats look new.
I have the gasket set ready to put it back together,do you think i should replace the chipped gear.?
I didn't know what to expect going by other peoples transfer cases,so i had my fingers crossed,it looks great,all the bearings and seats look new.
I have the gasket set ready to put it back together,do you think i should replace the chipped gear.?
Last edited by BATMOBILE1 on Fri Feb 02, 2018 8:37 am, edited 1 time in total.
94 locating Regt RA,57 Bty B troop 1982-1985.
32 Heavy Regt RA,57 Bty D droop 1985-1990.
M38 1952 ,restoration project
Dodge 1/2 ton WC-24 Chassis WC-6 body..combo.
Dodge 1951 M43 ,SOLD
Harley Davidson WLA.type IV. SOLD
32 Heavy Regt RA,57 Bty D droop 1985-1990.
M38 1952 ,restoration project
Dodge 1/2 ton WC-24 Chassis WC-6 body..combo.
Dodge 1951 M43 ,SOLD
Harley Davidson WLA.type IV. SOLD
-
- G-Command Sergeant Major
- Posts: 229
- Joined: Mon Nov 29, 2010 7:00 am
- Location: Hereford,U.K.
Re: Dodge WC-24/WC-7 Command car -project
Heres the original manuals I've been using to go by,the newer manual came through from Italy a couple of weeks back,it has a reprint date of 1985..?!
Very useful manuals and a must if you have a 1/2 ton..
Very useful manuals and a must if you have a 1/2 ton..
94 locating Regt RA,57 Bty B troop 1982-1985.
32 Heavy Regt RA,57 Bty D droop 1985-1990.
M38 1952 ,restoration project
Dodge 1/2 ton WC-24 Chassis WC-6 body..combo.
Dodge 1951 M43 ,SOLD
Harley Davidson WLA.type IV. SOLD
32 Heavy Regt RA,57 Bty D droop 1985-1990.
M38 1952 ,restoration project
Dodge 1/2 ton WC-24 Chassis WC-6 body..combo.
Dodge 1951 M43 ,SOLD
Harley Davidson WLA.type IV. SOLD
- 17thAirborne
- G-Lieutenant General
- Posts: 5847
- Joined: Mon Jun 21, 2004 5:42 am
- Location: Central TN
Re: Dodge WC-24/WC-7 Command car -project
How true
Oz
Feb 43 GPW 98532 USA 20206257
Oct 70 Land Rover Series 2a 25334079G NZ16GF36
http://gpw.castraponere.com/ (My Restoration Page)
Feb 43 GPW 98532 USA 20206257
Oct 70 Land Rover Series 2a 25334079G NZ16GF36
http://gpw.castraponere.com/ (My Restoration Page)
- zepher11
- G-Lieutenant General
- Posts: 4357
- Joined: Fri Aug 12, 2011 7:37 pm
- Location: The Real Northern CalifornIA
Re: Dodge WC-24/WC-7 Command car -project
I would replace the chipped gear if possible. I actually have an old transfer case that I was taking a few things from. Let me see if I can crack that thing open and see how the gears are. If they are good. I can donate the gear to your project if you are interested. I likely would never use it, and I would like to see it go to a good project. Hopefully, I can give it a go to disassemble the t-case tomorrow and let you know.BATMOBILE1 wrote: ↑Fri Feb 02, 2018 7:14 amHi Oz,
I didn't know what to expect going by other peoples transfer cases,so i had my fingers crossed,it looks great,all the bearings and seats look new.
I have the gasket set ready to put it back together,do you think i should replace the chipped gear.?
-
- G-Command Sergeant Major
- Posts: 229
- Joined: Mon Nov 29, 2010 7:00 am
- Location: Hereford,U.K.
Re: Dodge WC-24/WC-7 Command car -project
Thats very nice of you Zeph,yes i would be very interested ,lets hope the one you have is good,fingers crossed.zepher11 wrote: ↑Fri Feb 02, 2018 5:44 pmI would replace the chipped gear if possible. I actually have an old transfer case that I was taking a few things from. Let me see if I can crack that thing open and see how the gears are. If they are good. I can donate the gear to your project if you are interested. I likely would never use it, and I would like to see it go to a good project. Hopefully, I can give it a go to disassemble the t-case tomorrow and let you know.BATMOBILE1 wrote: ↑Fri Feb 02, 2018 7:14 amHi Oz,
I didn't know what to expect going by other peoples transfer cases,so i had my fingers crossed,it looks great,all the bearings and seats look new.
I have the gasket set ready to put it back together,do you think i should replace the chipped gear.?
Cheers.
94 locating Regt RA,57 Bty B troop 1982-1985.
32 Heavy Regt RA,57 Bty D droop 1985-1990.
M38 1952 ,restoration project
Dodge 1/2 ton WC-24 Chassis WC-6 body..combo.
Dodge 1951 M43 ,SOLD
Harley Davidson WLA.type IV. SOLD
32 Heavy Regt RA,57 Bty D droop 1985-1990.
M38 1952 ,restoration project
Dodge 1/2 ton WC-24 Chassis WC-6 body..combo.
Dodge 1951 M43 ,SOLD
Harley Davidson WLA.type IV. SOLD
-
- G-Command Sergeant Major
- Posts: 229
- Joined: Mon Nov 29, 2010 7:00 am
- Location: Hereford,U.K.
Re: Dodge WC-24/WC-7 Command car -project
Finally got a new driven gear for my transfer case,new old stock from Holland,all fitted ,nice easy job.all gaskets replaced and shims checked,going by the wear on the pinions it looks like i will probably have to replace them.
Also finished putting my MU winch together,all new gaskets fitted and finally back in the frame,and only a few scratches to the paint work..looking at other peoples restorations i don't know how they keep the previously restored and freshly painted parts from getting marked and dirty,i obviously need a bigger garage..- Attachments
-
- IMG_3657.JPG (165.26 KiB) Viewed 16985 times
-
- IMG_3655.JPG (180.29 KiB) Viewed 16985 times
94 locating Regt RA,57 Bty B troop 1982-1985.
32 Heavy Regt RA,57 Bty D droop 1985-1990.
M38 1952 ,restoration project
Dodge 1/2 ton WC-24 Chassis WC-6 body..combo.
Dodge 1951 M43 ,SOLD
Harley Davidson WLA.type IV. SOLD
32 Heavy Regt RA,57 Bty D droop 1985-1990.
M38 1952 ,restoration project
Dodge 1/2 ton WC-24 Chassis WC-6 body..combo.
Dodge 1951 M43 ,SOLD
Harley Davidson WLA.type IV. SOLD
Who is online
Users browsing this forum: No registered users and 60 guests